Water Heater Sediment Trap California

Sediment trap many locations require a sediment trap to be installed as close to the gas inlet as possible.

Water heater sediment trap california.

The utility companies can accid. It s basically a trap for moisture and sediment. It is a pipe that looks like a t and is intended to catch debris and moisture in your gas line. Different areas have different contaminants in the gas and the traps help catch these.

A sediment trap is required at water heaters. These traps prevent sediment and moisture from entering the firing chamber. 2010 cpc 1212 7 commentary. Most water heaters do not have a sediment trap in them.

See attached figure on page 4 for an acceptable sediment trap design. When replacing a storage tank water heater with a tankless water heater the gas line connected to the water heater and the pipe size of each section to the water heater shall be sized to meet the increased btu demand rating. Gas drip leg sediment traps the gas drip leg or sediment trap is located on the gas line running to your water heater usually below the gas control valve on the water heater. A drip simply needs to allow gravity to collect the liquid in the low spots.

Sediment traps are intentionally installed to help prevent sediment in the gas piping from getting into the gas valve or burner area of an appliance and fouling things up. The photo below shows 18. The sediment trap shall be either a tee fitting with a capped nipple in the bottom outlet as illustrated on page 5 or other device recog nized as an effective sediment trap. A sediment trap and a drip leg are often considered one in the same but not by the code.

Sediment trap the sediment trap is a new code requirement for water heaters. Sediment trap cpc 1211 8 a sediment trap shall be installed on the gas line downstream of the appliance shut off valve as close to inlet of the equipment as practical and upstream of the flex connector. A drip is only required when wet gas gas with a small amount of liquid present exists. A sediment trap is required per cpc section 1212 9.

Electric water heaters cees 150 2 b 1giid electric water heaters are allowed as long as they are an electric heat pump type and have a minimum energy factor of 2 80.