If the faucet remains on eventually the upper thermostat drops below 140 degrees which turns on the upper element and turns off the lower element.
Water heater upper lower thermostat settings.
Keep in mind that an electric water heater may have two thermostats one each for the upper and lower heating elements.
Testing water heater thermostats is important in locating water heater problems.
Most manufacturers recommend changing the lower thermostat setting while leaving the upper thermostat at the factory setting.
An upper and a lower located under two control panels.
Adjusting an electric hot water heater temperature thermostat setting.
It s not necessary that both thermostats will do the same work their work can vary according to the water heater unit.
The cold water turns on the lower element and begins preheating the lower tank.
1 turn off the circuit breaker to the water heater.
Keep in mind that the thermostat is factory preset to a recommended temperature and changing the setting may increase the potential for serious burns.
Thermometer for testing the water temperature.
The upper thermostat is the primary one that contains the high limit switch and the lower thermostat is used to detect the change in the temperature of the water.
The upper element stays off because there is still 140 degree water at the top of the tank.
The standard residential electric water heater control circuit consists of a manual reset high limit switch an upper thermostat lower thermostat two heating elements and wires.
I m guessing that setting your top thermostat to a 150 would give you small amount of really hot water rather quickly while setting the upper and lower thermostats evenly to a moderate temperature 115 125 would be your quickest way to get a full tank of hot water.
As a safety precaution shut off the electricity to the water heater before removing opening the panels.
Department of energy for each 10 degree reduction in water temperature you can save between 3 and 5 percent in energy costs.
When power is initially turned on to the unit the upper element is energized and heats the water in the upper third of the tank see figure 1.
Marker to mark the setting on your thermostat.
According to the u s.
When it goes bad you don t have any hot water at all.
The upper thermostat controls both the upper and lower element.
The majority of electric water heaters have two thermostats.
Adjusting an electric hot water heater temperature thermostat setting is a little more involved but still relatively easy.
